Galaxy GBS 10/350 (15-35 kg) Pyro-activated Professional Parachute system

ECOVERY SYSTEM, DRON, MULTICOPTER, UAV

Technical parametres
TYP	GBS 10/30	GBS 10/50	GBS 10/150	GBS 10/350	GBS 10/350 Speedy
Load range	up to 3 kg	3-5 kg	5-15 kg	15-35 kg	15-35 kg
Weight of the GBS unit (± 3%)	250 g	275 g	405 g	725 g	770 g
Minimum rescue height	from 5 m				from 30 m
Range of speed	0-80 km/h				220-300 km/h
Total time of full canopy opening	up to 1 s				1,5-2,5 s
Method of activation	Pyro-generator 150			Pyro-generator 350
Operating conditions	-20°C up to +40°C (version BASIC)
Dimension (mm)	ø100 x 70	ø100 x 80	ø100 x 110	ø100 x 190	ø100 x 190
Note: The weight show is with electronics system STADARD, does not include a carabiner and suspension system.

System GBS 10 has been tested by accredited Testing laboratory for emergency and parachute equipment – Air Force and Air Defence Military Technical Institute. Test report here

Endurance test of drone DJI Phantom 3 Professional with and without the system GALAXY GBS 10/30

Photogallery

 

 

 

 

 

 

 

During the challenging development process we focused on achieving a very high performance - the main goal in the whole design and production process of the ballistic rescue systems Series GBS 10. The system excels in:

• Minimum weight of Ballistic Rescue Unit GBS 10/ in modifications 30, 50, 150, 350, 350 Speedy, each in versions BASIC and TOUGH for professional users.
• The lightest ballistic rescue system in the world in the UAV weight category of 5-35 kg!
• Fast opening of the emergency parachute by using a pyrogenerator in time less then 1 sec. after system activation / similar system to an airbag in a car /.
• The range of use is from 3 to 35 kg. Four sizes of ballistic system are available as well as five types of parachute canopy. The speed range with guaranteed opening is from 0 to 80 km/h.
• Minimum rescue height already in the range of 5-8 m above the ground.
• GBS 10/350 Speedy – designed for fast-flying UAV models and unmanned systems for speed 220 kmph with opening time 1,5 sec. and for speed 300 kmph with opening time up to 2.5 sec. Minimum rescue height for this system is 30 m above the ground.
• Your UAV will not be damaged by a sudden failure of one of its systems and also the operational area under the UAV will be secured.
• GBS system is reusable - simple process of reloading and putting back to operation state immediately after the rescue in a very short time.
• Usable range for system activation is the same as the reach of your RC equipment.
• Ballistic rescue system has undergone a long-term testing by Institute of Aerospace Engineering VUT Brno and is certified by their Aviation Testing Institute.
• The design of the parachutes has been made on the basis of their test and measurement in the wind tunnel at VZLÚ (Aerospace Research and Test Establishment) ) in Prague to determine the correct figure of resistance CX.
• Professional version GBS 10 "TOUGH" fulfilling the requirement of RTCA / DO-160G (Environmental Conditions and Test Procedures for Airborne Equipment) guarantees the system"s functionality in extreme conditions - temperature range -40 °C to + 70 °C, atmospheric humidity of 95% at 55 °C, involving rain, dust and so on.
• This extremely powerful unit GBS 10 is protected by two patents and three utility models applied on the ballistic device, its equipment and the parachute.
• Easy installation of the ballistic rescue system and electronics to any unmanned UAV system.
• The GBS unit can be equipped with the motor disconnector.
• Safety connector with a red flag to prevent the activation of the ballistic rescue system during installation, transporting or manipulating as well as the light and the sound indication of Standby mode before takeoff.
• Service and production of GBS 10 system is provided by Galaxy GRS in Liberec - a company with 30 years of experience with ballistic parachute systems.

Test report for GBS 10/150	Application PV 2015-57	Utility model: 28 149	Patent no. 305548	Utility model: 28 081

History

1984

GRS Galaxy Ltd. developed the first series of ballistic systems GBS and GBS 1 2

2012

The company GRS Galaxy Ltd. The airlines began cooperation with the Institute Brno for the European space program SPARTAN

During the project, a knowledge-based project was launched ballistic rescue systems for drones future due to past experience and the high number of tests was completed in 2015 to develop a new series of ballistic systems GBS 10.

Thanks to 30 years of experience and collaboration with our partners GBS system 10 exceeds the competition in the following points:

the most common category of drones MTOW 7-8 kg :

- Lower weight of about cca 30%
- Lower sink by about cca 30%
- Thanks to a system using energy pyrogenerator we are able to proceed with the development of options for higher mass drones while maintaining low weight rescue system.

GBS system protected by two 10 worldwide patents, and several utility models